pH值对纳米零价铁吸附降解2,4-二氯苯酚的影响

在不同pH条件下,对纳米铁(颗粒粒径为30～40 nm)及其降解2,4-二氯苯酚反应体系进行取样,并进行透射电子显微镜(TEM)、扫描电子显微镜-能谱联用(SEM-EDX)以及电感耦合等离子体发射光谱(ICP-OES)等形貌观测与分析表征,以考察pH值在纳米零价铁降解氯酚反应过程中的影响和作用.结果表明,在降解2,4-二氯苯酚的过程中纳米铁由分散的颗粒逐渐团聚,其表面逐渐氧化,并最终被呈针状结晶的碱式氧化亚铁(FeOOH)覆盖,从而阻碍了降解反应的进一步进行.在酸性体系中,纳米零价铁的氧化和团聚现象有所缓解,尽管会造成一部分铁量的损失,但反应产生大量的亚铁离子参与并促进了脱氯降解反应的进行,反应过程中溶液pH值有逐渐升高的趋势.不同pH条件下,纳米铁对氯酚的去除率随pH值的降低而升高,酸性条件有利于提高氯酚的还原降解速率,当pH=3时,24 h内氯酚的去除率可达到90%以上.     

厌氧生物滴滤法脱除冷煤气中硫化氢的研究

水煤气中硫化氢在燃烧时会转变成二氧化硫,对环境产生污染。文章采用厌氧生物滴滤塔法对冷煤气进行脱硫处理。因煤气对氧的严格限制,通过设计生物滴滤塔,经挂膜驯化后在厌氧条件下对浓度在1~5 g/m3左右的硫化氢进行脱除处理,考察滴滤塔运行条件对脱除效果的影响。结果表明,生物挂膜25 d后,生物滴滤塔达到稳定,喷淋液pH值为2.23,ORP值为283 mV,溶解氧为0.4 mg/L,对溶液中硫离子氧化效率达到94%。滴滤塔在液气比0.15,空塔气速0.088 m/s,pH值5.0~7.0,填料高度为82 cm,塔温为25~30℃左右时,达到较优的运行条件,此时该滴滤塔对以CO、CO2、H2和1 940 mg/m3H2S组成的模拟水煤气的脱硫效率达91.2%。     

Shellac-coated iron oxide nanoparticles for removal of cadmium(II) ions from aqueous solution

This study describes a new effective adsorbent for cadmium removal from aqueous solution synthesized by coating a shellac layer, a natural biodegradable and renewable resin with abundant hydroxyl and carboxylic groups, on the surface of iron oxide magnetic nanoparticles. Transmission Electron Microscopy (TEM) imaging showed shellac-coated magnetic nanoparticle (SCMN) adsorbents had a core-shell structure with a core of 20 nm and shell of 5 nm. Fourier Transform Infrared Spectroscopic analysis suggested the occurrence of reaction between carboxyl groups on the SCMN adsorbent surface and cadmium ions in aqueous solution. Kinetic data were well described by pseudo second-order model and adsorption isotherms were fitted with both Langmuir and Freundlich models with maximum adsorption capacity of 18.80 mg/g. SCMN adsorbents provided a favorable adsorption capacity under high salinity conditions, and cadmium could easily be desorbed using mild organic acid solutions at low concentration.     

Rapid decolorization of Acid Orange II aqueous solution by amorphous zero-valent iron

Some problems including low treatment capacity, agglomeration and clogging phenomena, and short working life, limit the application of pre-treatment methods involving zero-valent iron (ZVI). In this article, ZVI was frozen in an amorphous state through a melt-spinning technique, and the decolorization effect of amorphous ZVI on Acid Orange II solution was investigated under varied conditions of experimental variables such as reaction temperature, ribbon dosage, and initial pH. Batch experiments suggested that the decolorization rate was enhanced with the increase of reaction temperature and ribbon dosage, but decreased with increasing initial solution pH. Kinetic analyses indicated that the decolorization process followed a first order exponential kinetic model, and the surface-normalized decolorization rate could reach 2.09 L/(m². min) at room temperature, which was about ten times larger than any previously reported under similar conditions. Recycling experiments also proved that the ribbons could be reused at least four times without obvious decay of decolorization rate and efficiency. This study suggests a tremendous application potential for amorphous ZVI in remediation of groundwater or wastewater contaminated with azo dyes.     

超声波/零价铁协同体系作用机理探讨

在超声波/零价铁协同体系中,探讨了OH.的产生途径及其影响因素,并分析了Fe0表面形态变化。结果表明:在超声波/零价铁体系中,羟基自由基的产生途径主要有四种:声空化导致水分子热解、Fenton反应、超声波与类Fenton反应的复合效应、铁粉颗粒效应;pH值过低或过高都不利于羟基自由基产生;当铁粉投加量为2.0g/L时最有利于羟基自由基产生;超声波通过冲刷、碎裂、清洗、气蚀和熔合等多种效应,活化和增强铁粉的表面性能。     

我国钢铁生产企业氮氧化物减排形势研究

针对国家"十二五"氮氧化物减排的紧迫形势,介绍了我国钢铁企业排放氮氧化物污染现状,提出烧结工序烟气氮氧化物控制是钢铁生产企业氮氧化物减排的重点,在对相关技术优缺点进行分析的基础上,总结了存在的主要问题、困难和发展趋势,提出了钢铁行业氮氧化物减排的对策和建议,为我国氮氧化物污染控制提供支撑。     

Steady performance of a zero valent iron packed anaerobic reactor for azo dye wastewater treatment under variable influent quality

Zero valent iron (ZVI) is expected to help create an enhanced anaerobic environment that might improve the performance of anaerobic treatment. Based on this idea, a novel ZVI packed upflow anaerobic sludge blanket (ZVI-UASB) reactor was developed to treat azo dye wastewater with variable influent quality. The results showed that the reactor was less influenced by increases of Reactive Brilliant Red X-3B concentration from 50 to 1000 mg/L and chemical oxygen demand (COD) from 1000 to 7000 mg/L in the feed than a reference UASB reactor without the ZVI. The ZVI decreased oxidation-reduction potential in the reactor by about 80 mV. Iron ion dissolution from the ZVI could buffer acidity in the reactor, the amount of which was related to the COD concentration. Fluorescence in situ hybridization test showed the abundance of methanogens in the sludge of the ZVI-UASB reactor was significantly greater than that of the reference one. Denaturing gradient gel electrophoresis showed that the ZVI increased the diversity of microbial strains responsible for high efficiency.     

零价铁还原和吸附去除水中污染物的研究进展

近年来,零价铁以其低毒、廉价、易操作且对环境不会产生二次污染等优点,在水污染治理中受到重视。文章介绍了零价铁处理污水的机理,对利用零价铁的还原和吸附作用去除污水中的氯代有机物、硝基芳香族化合物、偶氮染料、重金属、高氯酸盐、硝酸盐等的研究情况进行了综述,指出了零价铁废水处理技术的研究方向。     

板式生物滴滤塔高效净化硫化氢废气的研究

采用营养液分层喷淋、pH分别在线控制(pH 2.5、 4.5、 6.5)的板式生物滴滤塔(plate type-biotrickling filter, PTBTF)净化H₂S废气,考察PTBTF于挂膜启动及稳定运行阶段对H₂S的降解性能.结果表明,PTBTF系统在14 d内即完成挂膜,对浓度为188.6mg·m^-3的H₂S去除率达到100%;在进口浓度100～1000mg·m^-3、空床停留时间(EBRT)28～4 s的条件下,H₂S的去除率可达到99%以上;当H₂S去除率≥90%时, PTBTF系统的最大去除负荷随EBRT(3.3～6 s)的增加而增大,EBRT 6 s的最大去除负荷达到1019.0g·(m³·h)^-1;上、中、下3层填料对H₂S的去除负荷随进口H₂S负荷的波动呈显著变化;通过荧光染色观察填料上的细胞数,发现在挂膜阶段微生物数量增长明显,第125 d上层、中层和下层填料上的菌落数(以干填料计)分别达到了1.29×10⁷、 5.47×10⁸和1.07×10⁹个·g^-1;采用扫描电镜观察填料表面的生物膜,可见上填料层和下填料层的优势菌分别为杆菌和丝状菌;利用变性梯度凝胶电泳初步揭示了系统运行过程中生物群落的演替规律;通过对产物的分析,确定该PTBTF系统降解H₂S后主要产生SO^2-₄和单质硫.     

海水淡化水在既有管网输配的铁释放控制研究

由于具有强腐蚀性,海水淡化水在既有市政管网输配过程中往往会产生严重的"红水"现象,主要是由于管网中铁的释放.为了研究控制既有管网中铁释放的有效措施,对管龄为30～40 a的钢管和灰口铸铁管内壁的腐蚀瘤进行分析,主要组成物质为Fe3O4和FeOOH;选择腐蚀较严重的钢管进行静态浸泡试验,重点分析了自来水和淡化水的掺混比、pH值、碱度、氯离子和硫酸根离子对铁释放的影响,并以铁浓度为控制量,初步给出了海水淡化水在既有管网中安全输配所需满足的水质条件:自来水和淡化水的掺混比≥2∶1,pH值在7.6以上,碱度>200 mg.L-1.